Generac 005735-0 Manual Do Utilizador

It is important to perform service as specified in the Maintenance 
Schedule for proper generator operation, and to ensure that the generator 
complies with the applicable emission standards for the duration of its 
useful life. Service and repairs may be performed by any capable person 
or repair shop. Additionally, emissions critical maintenance must be 
performed as scheduled in order for the Emissions Warranty to be valid. 
Emissions critical maintenance consists of servicing the air filter and spark 
plugs in accordance with the Maintenance Schedule.

Follow the calendar intervals. More frequent service is required when 
operating in adverse conditions noted below.

Check Oil Level 

At Each Use

Change Oil ‡ 

*Every 100 hours or Every Season

Check Valve Clearance 

***Every Season

Service Air Filter 

** Every 200 hours or Every Season

Replace Spark Plug 

Every Season

‡  Change oil after first 30 hours of operation then every season.
*  Change oil and oil filter every month when operating under heavy load or in high 

temperatures.

** Clean more often under dirty or dusty operating conditions.  Replace air filter 

parts if they cannot be adequately cleaned.

*** 

Check valve clearance and adjust if necessary after first 50 hours of 

operation and every 100 hours thereafter.

Rated Max. Power

15.0 kW

17.5 kW

Surge Power

22.5 kW

26.25 kW

Rated AC Voltage

120/240

120/240

Rated Max AC Load
Current @ 240V

62.5 Amps

72.9 Amps

Current @ 120V

125.0 Amps

145.8 Amps

Rated Frequency

60 Hz @ 3600 RPM

60 Hz @ 3600 RPM

Phase

Single Phase

Single Phase

Rated DC Voltage

12 Volts

12 Volts

Rated Max DC Load
Current @ 12 Volts

10 Amperes

10 Amperes

Weight

373 lbs.

400 lbs.

Rated Horsepower @ 3600 RPM 30
Displacement

992cc

Spark Plug Type

Champion RC14YC or Equivalent

Spark Plug Gap

0.040 inch or (1.01 mm)

Gasoline Capacity

16 U.S. gallons

Oil Type

Summer – SAE 30, Winter – 
5W-30 Synthetic or 10W-30 

Oil Capacity

w/ Filter Change = 1.7 Qts., w/o 
Filter Change = 1.4 Qts.

Run Time/Fuel Consumption-1/2 
Load

10 Hours / 1.6 gallons per hour

The Environmental Protection Agency (and California Air Resource Board 
for generators certified to CA standards) require(s) that this generator 
comply with exhaust and evaporative emission standards. Locate the 
emissions compliance decal on the engine to determine what standards 
the generator meets. This generator is certified to operate on gasoline. The 
emission control system consists of the following:

•  Air Induction System

~  Intake Pipe / Manifold

~  Air Cleaner

•  Fuel System

~ Carburetor

~  Fuel Tank / Cap

~  Fuel Lines

~  Evaporative Vent Lines

~  Carbon Canister (for CA engines only)

•  Ignition System

~  Spark Plug

~  Ignition Module

•  Exhaust System

~  Exhaust Manifold

~ Muffler

~  Catalyst (for CA engines only).

The warranty of the generator does not cover items that have been 
subjected to operator abuse or negligence. To receive full value from the 
warranty, the operator must maintain the generator as instructed in this 
manual.

Some adjustments will need to be made periodically to properly maintain 
the generator.

All adjustments in the Maintenance section of this manual should be made 
at least once each season. Follow the requirements in the "Maintenance 
Schedule" chart.

Maintenance