Golden Technologies GC440 Benutzerhandbuch

Seite von 37
Companion Owner's Manual: GC240, GC340, GC440
 
Companion  
28 
 
X. CARE AND MAINTENANCE
 
BATTERIES AND CHARGING 
Battery maintenance is the most important part of maintaining your scooter. Keeping the 
batteries fully charged helps to extend battery life. Use the following guidelines to help keep 
your batteries in optimum condition. 
 
• 
To break-in the batteries, completely run 
down the batteries 4-5 times. This will in-
crease battery life and help them retain their 
maximum charge. 
• 
For daily use, keep batteries fully charged. 
We recommend that you plug in the off-board 
charger after each use and charge 6-8 hours. 
• 
If you are not going to use the scooter for 
more than a week, fully charge the batteries 
and then disconnect them from the scooter. 
See figure 17. 
 
To Charge the Batteries: 
The charger for all Companion models is an off-
board charger. To charge the batteries, Plug the 
charger into the charger port on the tiller. See 
figure 28.  
 
Battery Maintenance 
GEL-cell or AGM and SLA deep-cycle batteries are used for operating Golden Companion 
scooters. 
• 
These batteries are maintenance free. 
• 
There is no danger of spillage or leakage, so these batteries are safely transportable on 
aircraft, busses, trains, etc. 
• 
By following the procedures set out in this manual, you can expect extended life from 
your Golden Companion’s batteries. 
 
If the battery terminals become corroded: 
• 
Corrosion can cause a poor electrical connection 
and operational problems. 
• 
Clean corroded battery terminals with a stiff brush 
and a mix of baking soda and water. 
 
Battery Cable Installation 
If it becomes necessary to install new batteries, you 
may need to change each battery harness. See figure 
29. Use a machine screw, a split washer, and a nut to 
attach the red cable ring terminal to the positive (+) 
battery terminal. Use a machine screw, a split washer, 
and a nut to attach the black cable ring terminal to the 
negative (-) battery terminal.
 
FIGURE 29. BATTERY HARNESS 
FIGURE 28. CHARGER PORT 
POSITIVE (+) TERMINAL 
NEGATIVE  (-) TERMINAL