Vogelzang International NORSEMANTM SOlid FuEl WARM AiR FuRNAcE 2500 Benutzerhandbuch
Page
/
NORSEMAN™ 1500/2500 FuRNAcE
VGZ-018 / 0805.1
sAFEtY iNstRUctioNs
SAFETY NOTICE: IF ThIS FURNACE IS NOT PROPERLY INSTALLED, A hOUSE/BUILDINg FIRE
mAY RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDINg OR FIRE OFFICIALS ABOUT
PERmITS, RESTRICTIONS, AND INSTALLATION REqUIREmENTS FOR YOUR AREA.
mAY RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDINg OR FIRE OFFICIALS ABOUT
PERmITS, RESTRICTIONS, AND INSTALLATION REqUIREmENTS FOR YOUR AREA.
READ ALL INSTRUCTIONS CAREFULLY.
Refer to instruction panels, caution and
warning plates on furnace for additional
information.
1. This furnace is designed for
warning plates on furnace for additional
information.
1. This furnace is designed for
INDOOR
INSTALLATION ONLY.
2. DO NOT attempt to retrofit this unit with any type
of water coil or water jacket.
3. The installation of this furnace MuST comply
with your local building code rulings. Please
observe the clearances to combustibles (see
reference figures 1–3). Do not place furniture
or other objects within the clearance area.
observe the clearances to combustibles (see
reference figures 1–3). Do not place furniture
or other objects within the clearance area.
4. Verify that the furnace is properly installed be-
fore firing for the first time. Obtain the services
of a professional licensed installer familiar with
all aspects of safe and correct installation. DO
NOT use temporary or makeshift compromises
during installation.
of a professional licensed installer familiar with
all aspects of safe and correct installation. DO
NOT use temporary or makeshift compromises
during installation.
5. DO NOT store wood, flammable liquids or other
combustible materials too close to the unit. Refer
to the certification label on back of unit and refer-
ence clearance instructions in this manual.
to the certification label on back of unit and refer-
ence clearance instructions in this manual.
6.
DO
NOT INSTALL ThIS FURNACE IN A mO-
BILE hOmE, mANUFACTURED hOmE, TENT
OR TRAILER – No ExcEptioNs! (hUD Fed-
eral Standard: 24 CFR Ch.XX)
OR TRAILER – No ExcEptioNs! (hUD Fed-
eral Standard: 24 CFR Ch.XX)
7. If any parts are missing or defective, please no-
tify the manufacturer or dealer immediately. DO
NOT OPERATE A STOVE THAT IS MISSING
ANY PARTS
NOT OPERATE A STOVE THAT IS MISSING
ANY PARTS
8. Always connect this furnace to a chimney and
vent to the outside. NEVER vent to another
room or inside a building. DO NOT cONNEcT
THIS uNIT TO A cHIMNEY FLuE SERVING
ANOTHER APPLIANcE.
room or inside a building. DO NOT cONNEcT
THIS uNIT TO A cHIMNEY FLuE SERVING
ANOTHER APPLIANcE.
9.
DO NOT CONNECT this furnace to an aluminum
Type B gas vent. This is not safe. use approved
masonry or a uL 103 HT Listed Residential
Type and Building Heating Appliance chimney.
use a 6” diameter chimney or larger, that is high
enough to provide required draft. (See specifics
in installation instructions).
Type B gas vent. This is not safe. use approved
masonry or a uL 103 HT Listed Residential
Type and Building Heating Appliance chimney.
use a 6” diameter chimney or larger, that is high
enough to provide required draft. (See specifics
in installation instructions).
10. Inspect flue pipes, pipe joints, and flue pipe
seals regularly to ensure that smoke and flue
gases are not drawn into, and circulated by the
air circulation system.
gases are not drawn into, and circulated by the
air circulation system.
11. cleaning of this furnace, is especially important at
the end of the heating season. Accumulated ash
attracts moisture and may cause corrosion during
the summer months.
attracts moisture and may cause corrosion during
the summer months.
12. B e s u r e t h a t y o u r c h i m n e y i s s a fe l y
constructed and in good repair. Have the chimney
inspected by the fire department or a qualified
inspector. Your insurance company may be able to
recommend a qualified inspector.
inspected by the fire department or a qualified
inspector. Your insurance company may be able to
recommend a qualified inspector.
13. creosote or soot may build up in the chimney
connector and/or chimney and cause a house,
building or chimney fire. Inspect the chimney
connector and chimney twice monthly during the
heating season and clean if necessary. (See chim-
ney Maintenance, page 18).
building or chimney fire. Inspect the chimney
connector and chimney twice monthly during the
heating season and clean if necessary. (See chim-
ney Maintenance, page 18).
14. To prevent injury, do not allow anyone to use this
furnace who is unfamiliar with the correct operation
of the furnace.
of the furnace.
15. Do not operate fur nace while under the
influence of drugs or alcohol.
16. Ashes should not be allowed to accumulate higher
than the ash pan. Dispose of ashes in a metal con-
tainer with a tight fitting lid. Keep the closed con-
tainer on a noncombustible floor or on the ground,
well away from all combustible materials. Keep the
ashes in the closed container until all cinders have
thoroughly cooled. The ashes may be buried in the
ground or picked up by a refuse collector.
tainer with a tight fitting lid. Keep the closed con-
tainer on a noncombustible floor or on the ground,
well away from all combustible materials. Keep the
ashes in the closed container until all cinders have
thoroughly cooled. The ashes may be buried in the
ground or picked up by a refuse collector.
17. Build several small fires on first use. This will help
to “season” the cast iron parts and avoid cracking.
Allow furnace to cool between firings.
Allow furnace to cool between firings.
18. The special paints used on your furnace may
give off some smoke and an odor while they
are curing during the first 12 to 15 fires.
Additional smoke and odor may be emitted from
the light oils used in construction of the fire box.
This should disappear after a short period of time
and not occur again. Persons with lung conditions
or owners of susceptible domestic pets (such as
birds) should take prudent precautions. Open win-
dows and doors as needed to clear smoke and/or
odor. Paint discoloration will occur if the furnace
is over fired.
are curing during the first 12 to 15 fires.
Additional smoke and odor may be emitted from
the light oils used in construction of the fire box.
This should disappear after a short period of time
and not occur again. Persons with lung conditions
or owners of susceptible domestic pets (such as
birds) should take prudent precautions. Open win-
dows and doors as needed to clear smoke and/or
odor. Paint discoloration will occur if the furnace
is over fired.
19. This furnace has a painted surface which is
durable but it will not stand rough handling or
continued on next page