Bryant 577D----A User Manual
1
577D----A
EVOLUTIONR
15 SEER SINGLE--PACKAGED AIR CONDITIONER AND GAS FURNACE
SYSTEM WITH PURONR (R--410A) REFRIGERANT
SINGLE PHASE
2--5 NOMINAL TONS (SIZES 24--60)
Installation Instructions
EQUIPMENT OPERATION HAZARD
Failure to follow this caution may result in improper unit
Failure to follow this caution may result in improper unit
operation.
OAT sensor must be field installed. See Accessory
Installation for more details.
CAUTION
!
EQUIPMENT OPERATION HAZARD
Failure to follow this caution may result in improper unit
Failure to follow this caution may result in improper unit
operation.
This Evolutionr unit is designed for use with an Evolution
User Interface.
CAUTION
!
NOTE:
Read the entire instruction manual before starting the
installation.
TABLE OF CONTENTS
PAGE
SAFETY CONSIDERATIONS
2
. . . . . . . . . . . . . . . . . . . . . . . . .
INTRODUCTION
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RECEIVING AND INSTALLATION
2--13
. . . . . . . . . . . . . . . . .
Check Equipment
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identify Unit
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspect Shipment
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Provide Unit Support
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Roof Curb
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Slab Mount
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Provide Clearances
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rig and Place Unit
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rigging/Lifting of Unit
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Select and Install Ductwork
9
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Configuring Units for Downflow (Vertical) Discharge
10
. . .
Provide for Condensate Disposal
10
. . . . . . . . . . . . . . . . . . . . .
Install Flue Hood
11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Install Gas Piping
11
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Install Electrical Connections
12
. . . . . . . . . . . . . . . . . . . . . . . .
High--Voltage Connections
12
. . . . . . . . . . . . . . . . . . . . . . . .
Routing Power Leads Into Unit
12
. . . . . . . . . . . . . . . . . . . . .
Connecting Ground Lead to Ground Screw
12
. . . . . . . . . . .
Routing Control Power Wires
13
. . . . . . . . . . . . . . . . . . . . .
Accessory Installation
13
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Special Procedures for 208--v Operation
13
. . . . . . . . . . . . . .
PRE--START--UP
16
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
START--UP
16--29
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Unit Start--Up and Troubleshooting
16
. . . . . . . . . . . . . . . . . . .
Sequence of Operation
23
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check for Refrigerant Leaks
28
. . . . . . . . . . . . . . . . . . . . . . . . .
Start--Up Adjustments
28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A09032
Fig. 1 -- Unit 577D----A
Checking Cooling and Heating Control Operation
28
. . . . . .
Checking and Adjusting Refrigerant Charge
28
. . . . . . . . . . .
Refrigerant Charge
29
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
No Charge
29
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Charge Cooling
29
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To Use Cooling Charging Charts
29
. . . . . . . . . . . . . . . . . . . .
Non--Communicating Emergency Cooling/Heating Mode
29
. .
MAINTENANCE
31--34
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Filter
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Indoor Fan and Motor
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inducer Blower
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limit Switch
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Burner Ignition
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Main Burners
31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inducer Pressure Switch
32
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outdoor Coil, Indoor Coil, and Condensate Drain Pan
32
. . . . .
Outdoor Fan
32
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Controls and Wiring
32
. . . . . . . . . . . . . . . . . . . . . . .
Refrigerant Circuit
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Indoor Airflow
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pressure Switches
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loss--of--Charge Switch
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
High--Pressure Switches
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Copeland Scroll Compressor (Puron
®
Refrigerant)
33
. . . . . . . .
Refrigerant System
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Refrigerant
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compressor Oil
33
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Servicing Systems on Roofs with Synthetic Materials
33
. . . .
Liquid--Line Filter Drier
34
. . . . . . . . . . . . . . . . . . . . . . . . . .
Puron (R--410A) Refrigerant Charging
34
. . . . . . . . . . . . . . .
TROUBLESHOOTING
34
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FINAL CHECKS
35
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CARE AND MAINTENANCE
35
. . . . . . . . . . . . . . . . . . . . . . . .
START--UP CHECKLIST
39
. . . . . . . . . . . . . . . . . . . . . . . . . . . .