Ramsey Electronics LEAD ACID BATTERY CHARGER KIT User Manual

Page of 24
LABC1 
• 18  
SAFETY CONSIDERATIONS 
All lead-acid batteries produce Hydrogen and Oxygen gas during the electro-
chemical recharging process. The production of these gases is increased if 
overcharging occurs, commonly caused by too high of a charge voltage. 
Sealed battery designs plan on the recombination of Oxygen at the same rate 
it is produced, therefore eliminating the explosive mixture. Any Hydrogen 
which is produced will diffuse through the plastic container and as long as the 
sealed battery is not in a sealed enclosure, the hydrogen will harmlessly 
disperse into the atmosphere.  
It is good practice to use adequate ventilation even with sealed batteries due 
to the possibility of unforeseen problems. Should something happen, the 
battery may vent as needed to prevent pressure build up. 
Remember, the gases that form while charging lead acid batteries are 
extremely explosive! 
Never charge a battery around an open flame or 
anything that may cause a spark that may ignite the venting gas! 
Another point to enforce is that a battery should never be left to charge 
unattended. Any charging battery should be considered an explosive fire 
hazard and deserves full attention of the person charging it. The battery’s 
sulfuric acid can cause bodily harm to you and the environment around you 
should an explosion occur. If you should hear excessive bubbling (kind-of like 
a bowl of Rice Krispies
 with milk) coming from the battery, cease charging 
immediately and investigate the situation. Your safety is your responsibility 
and the end use of your LABC1 or any other charger is up to you to use 
responsibly. 
Always wear safety glasses and protective gloves while working with lead acid 
batteries. You might even find it beneficial to wear your father’s ‘polyester 
leisure suit’ (yep… you finally found a use for that old thing!) to protect 
yourself from corrosive acid that might ruin a " normal human’s” clothing! 
Notes on Operation 
1) First and foremost, the LABC1 has been designed to work with 12 Volt 
Lead Acid Batteries only. Modification for other voltages is not encouraged. 
The easiest way to check to see if your battery is compatible with the LABC1 
is to carefully read the information stamped on the battery itself or in the 
manufacturer’s datasheet. Since a 12V battery is composed of six 2 Volt cells 
in series, count the number of vent covers on top of the battery as a quick 
check! An example would be: three vents equals 6 Volts equals no good! 
2) The value of R4 has been conservatively set for 18K to avoid the possibility 
of excessive Hydrogen gas build-up while charging. Remember from before