Honeywell Liquid Cooled 45kW Home Standby Generator Owner's Manual

INTRODUCTION

Thank you for purchasing this model of the stationary emergency 
generator product line.
Every effort was expended to make sure that the information and 
instructions in this manual were both accurate and current at the 
time the manual was written. However, the manufacturer reserves 
the right to change, alter or otherwise improve this product(s) at 
any time without prior notice.

If any portion of this manual is not understood, contact the nearest 
Service Dealer for starting, operating and servicing procedures.
Throughout this publication, and on tags and decals affixed to the 
generator, DANGER, WARNING, CAUTION and NOTE blocks are 
used to alert personnel to special instructions about a particular 
service or operation that may be hazardous if performed incor-
rectly or carelessly. Observe them carefully. Their definitions are 
as follows:

and will be found within the regular text body of this manual.
These safety warnings cannot eliminate the hazards that they 
indicate. Common sense and strict compliance with the special 
instructions while performing the service are essential to prevent-
ing accidents.
Four commonly used safety symbols accompany the DANGER, 
WARNING and CAUTION blocks. The type of information each 
indicates is as follows:

n









The operator is responsible for proper and safe use of the equip-
ment. The manufacturer strongly recommends that the operator 
read this Owner's Manual and thoroughly understand all instruc-
tions before using this equipment. The manufacturer also strongly 
recommends instructing other users to properly start and operate 
the unit. This prepares them if they need to operate the equipment 
in an emergency.
For safety reasons, the manufacturer recommends that this 
equipment be installed, serviced and repaired by a Service 
Dealer or other competent, qualified electrician or installation 
technician who is familiar with applicable codes, standards and 
regulations. The operator also must comply with all such codes, 
standards and regulations.

It is the operator's responsibility to perform all safety checks, to 
make sure that all maintenance for safe operation is performed 
promptly, and to have the equipment checked periodically by a 
Service Dealer. Normal maintenance service and replacement of 
parts are the responsibility of the owner/operator and, as such, 
are not considered defects in materials or workmanship within the 
terms of the warranty. Individual operating habits and usage con-
tribute to the need for maintenance service.
Proper maintenance and care of the generator ensure a minimum 
number of problems and keep operating expenses at a minimum. 
See a Service Dealer for service aids and accessories.
Operating instructions presented in this manual assume that the 
generator electric system has been installed by a Service Dealer or 
other competent, qualified contractor. Installation of this equipment 
is not a “do-it-yourself” project.

When the generator requires servicing or repairs, simply contact 
a Service Dealer for assistance. Service technicians are factory-
trained and are capable of handling all service needs.
When contacting a dealer about parts and service, always supply 
the complete Model Number, Serial Number and Type Code (where 
applicable) from the DATA LABEL that is affixed to the unit.

Safety004  Rev

. F  05/10

Safety Instructions

n