White Rodgers F92-0656 Leaflet

www

www.w

.white-r

hite-r

hite-rodg

odg

odger

ers

s.com

.com

F92-0656 & F92-0935

PART NO. 37-5380B

Replaces 37-5380A

0640

Regulated L.P. to Natural Gas

Conversion Kits

INSTALLATION INSTRUCTIONS

APPLICATION

This conversion kit shall be installed by a qualified

This conversion kit shall be installed by a qualified
service agency in accordance with the manufacturer's

service agency in accordance with the manufacturer's

service agency in accordance with the manufacturer's
instructions and all applicable codes and requirements

instructions and all applicable codes and requirements

instructions and all applicable codes and requirements
of the authority having jurisdiction. If the information in

of the authority having jurisdiction. If the information in

of the authority having jurisdiction. If the information in
these instructions is not followed exactly, a fire, explo-

these instructions is not followed exactly, a fire, explo-

these instructions is not followed exactly, a fire, explo-
sion, or production of carbon monoxide may result,

sion, or production of carbon monoxide may result,

sion, or production of carbon monoxide may result,
causing property damage, personal injury, or loss of

causing property damage, personal injury, or loss of

causing property damage, personal injury, or loss of
life. The qualified service agency performing the work

life. The qualified service agency performing the work

life. The qualified service agency performing the work
assumes the responsibility for the proper conversion of

assumes the responsibility for the proper conversion of

assumes the responsibility for the proper conversion of
this appliance with this kit.

this appliance with this kit.

These regulated L.P. Gas to regulated Natural Gas conver-
sion kits allow the 36C, 36D, 36E, 36G, 36H and 36J Series
gas valves to be used on natural gas applications. T

These

hese

con

conv

ver

ersion kits ar

sion kits ar

sion kits are f

e f

e for use on all sing

or use on all sing

or use on all single sta

le sta

le stag

e,,,,, f

fast and

ast and

slo

slow open models and 36G

w open models and 36G

w open models and 36G,,,,, 36H and 36J tw

36H and 36J tw

36H and 36J two sta

o sta

o stag

models

models.....

TO CONVERT FROM L.P. TO NATURAL GAS

1. Remove regulator cover screw.
2. Remove regulator adjustment screw (beneath the cover

screw).

3. Remove L.P. regulator spring from regulator sleeve.
4. Insert the natural gas regulator spring (provided in the

conversion kit) into the regulator sleeve.

5. Replace the regulator adjustment screw. Then adjust the

outlet pressure to the appliance manufacturer's specified
outlet pressure.

6. Replace the regulator cover screw.
7. Attach the WARNING label (provided in the kit) to the gas

valve where it can be readily seen. Also attach the small
round NAT. GAS label to the top of the regulator cover
screw.

8. If present, pilot burner is to be used, the pilot orifice must

be replaced.

Conversion back to L.P. Gas use may be made at a later
date by retaining the L.P. spring (removed in step 3, above)
and following the same procedures (except for burner
pressure given in step 5).

FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING OR OPERATING THIS

FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING OR OPERATING THIS
CONTROL COULD CAUSE PERSONAL INJURY AND/OR PROPERTY DAMAGE.

CONTROL COULD CAUSE PERSONAL INJURY AND/OR PROPERTY DAMAGE.

WARNING

Figure 1. 36C and 36D

Models

Regulator

Cover Screw

Regulator

Spring

VENT

Plastic Regulator

Adjustment

Screw

Regulator

Sleeve

Regulator

Cover

Screw

Regulator

Spring

Plastic

Regulator

Adjustment

Screw

Figure 2. 36E, 36G and 36J

Single Stage

Models

Regulator

Sleeve

Regulator

Cover Screw

Regulator Spring

Plastic Regulator

Adjustment Screw

If low outlet
pressure greater
than 5" W.C. is
required, use an
additional kit to
convert low pressure.

Figure 3. 36G and 36J

2-Stage models

Regulator

Cover Screw

Regulator Spring

Plastic Regulator

Adjustment Screw

If low outlet pressure greater
than 5" W.C. is required, use
an additional kit to
convert low pressure.

Figure 4. 36H Single Stage

and 2-Stage models

VALVE CONVERTED FOR USE ON
NATURAL GAS. IMPROPER OPERATION
COULD RESULT IN DEATH OR SERIOUS
INJURY.

Figure 5. Contents of kit

WARNING Label

Natural Gas

Regulator

Spring

Natural Gas

Label

WARNING

SOUPAPE CONVERTIE POUR USAGE
SUR GAZ NATUREL.
UN FONCTIONNEMENT INAPPROPRIÉ
PEUT PROVOQUER LA MORT OU DES
BLESSURES GRAVES.

MISE EN GARDE

NAT

GAS