Lincoln Electric SVM197-A Manual De Usuario
ELECTRICAL DIAGRAMS
G-8
POWERARC® 5500
SCHEMATIC - CODE 11404 (S26882)
S26882
POWER ARC 5500 (HONDA)
MACHINE SCHEMATIC
NONE
S26008
MAP
DJS
-
DO NOT SCALE THIS DRAWING
DRAWN BY:
DESIGN INFORMATION
ENGINEER:
APPROVED:
EQUIPMENT TYPE:
SUBJECT:
SCALE:
NA
CRM38121
1
PAGE ___ OF ___
1
ENGINEERING CONTROLLED
MANUFACTURER:
MANUFACTURER:
No
NEW
A
THIS DOCUMENT CONTAINS PROPRIETARY INFORMATION OWNED BY LINCOLN GLOBAL, INC. AND MAY NOT BE DUPLICATED, COMMUNICATED
TO OTHER PARTIES OR USED FOR ANY PURPOSE WITHOUT THE EXPRESS WRITTEN PERMISSION OF LINCOLN GLOBAL, INC.
TO OTHER PARTIES OR USED FOR ANY PURPOSE WITHOUT THE EXPRESS WRITTEN PERMISSION OF LINCOLN GLOBAL, INC.
PROPRIETARY & CONFIDENTIAL:
11/13/2006
WITH PUBLISHED STANDARDS.
MATERIAL TOLERANCE (" ") TO AGREE
ON ALL ANGLES IS ± .5 OF A DEGREE
t
ON 3 PLACE DECIMALS IS ± .002
ON 2 PLACE DECIMALS IS ± .02
UNLESS OTHERWISE SPECIFIED TOLERANCE:
MANUFACTURING TOLERANCE PER E2056
CHANGE DETAIL:
REFERENCE:
MATERIAL
DISPOSITION:
DISPOSITION:
APPROVAL
DATE:
DATE:
PROJECT
NUMBER:
NUMBER:
DOCUMENT
NUMBER:
NUMBER:
DOCUMENT
REVISION:
REVISION:
S268
82
EXCITER
WINDING
7
9
7
9
AC
AC
(+)
(-)
+
RHEOSTAT
N/C
N/C
REVOLVING FIELDS
(ROTOR)
7 OHMS @ 75
v
F
9 OHMS @ OPERATING
TEMPERATURE
CW
40 TO 45
VDC
MAX
RHEOSTAT
AUX.
POWER
WINDING
3
6
3
6
5
6 CAVITY
CONNECTOR
STATOR
END
END
BRKT.
GROUND
GROUND
OIL LEVEL
SWITCH
SWITCH
CB2
20A
CB1
20A
130 VAC@ MAX
RHEOSTAT/
NO LOAD
RHEOSTAT/
NO LOAD
130 VAC
@ MAX
RHEOSTAT/
NO LOAD
@ MAX
RHEOSTAT/
NO LOAD
WELD
WINDING
W1
W2
60 VAC
@ MAX
RHEOSTAT/
NO LOAD
60 VAC
@ MAX
RHEOSTAT/
NO LOAD
L1 - REACTOR
STATOR
AC
AC
(+)
(-)
5
RECP PANEL GND STUD
2
WELD OUTPUT
STUDS
J1 240V
20A
35 VAC
MAX
RHEOSTAT
ENGINE
MAGNETO
IGNITION
STOP
RUN
SPARK
PLUG
205
FLASH FROM
ENGINE MAGNETO
GND-C
GND-D
MAX RHEOSTAT FIELD AMPS =
5.75 TO 6.0 @ 75 deg F
4.25 TO 4.5 @ OPERATING
5.75 TO 6.0 @ 75 deg F
4.25 TO 4.5 @ OPERATING
TEMPERATURE
FLASHING AMPS TO ROTOR WITH GENERATOR
LEAD 7 DICONNECTED AND ENGINE RUNNING
AT 3700 RPM = 0.15 TO 0.25 AMPS
LEAD 7 DICONNECTED AND ENGINE RUNNING
AT 3700 RPM = 0.15 TO 0.25 AMPS
Locatedontop
of engine
blower housing.
Locatedinsideengineblower housing.
Mountedtoside
of engineblock
below run/stop
switch.
Locatedinsideenginecrankcase.
Locatedinsideenclosureontopof generator.
Receptacleslocatedoncontrol panel.
Circuit breakerslocated
underneathcontrol
panel below receptacles
Connector
locatedinside
enclosureat
topof
generator.
Rheostat located
oncontrol panel.
Excitation rectifier locatedin
enclosureonsheet metal at
topof generator near
bearingend.
Flashing rectifier and
filter capacitor
locatedinenclosure
behindcontrol panel
inmoldedplastic
mountingbracket.
3.3 Ohms/ 100 Watt
600 uf
IF OIL LEVEL IS TOO LOW OIL LEVEL
SWITCH CLOSES GROUNDING
SWITCH CLOSES GROUNDING
ENGINE MAGNETO VIA OIL LEVEL
MODULE PREVENTING ENGINE
MODULE PREVENTING ENGINE
FROM STARTING OR RUNNING.
SWITCH
HOURMETER/
TACHOMETER
If equipped,
hourmeter
/tachometer
located
oncontrol
panel.
Hourmeter is powered by an internal non-replaceable battery.
RPM and running time is measured by detector wire wrapped
around the sparkplug wire. Meter displays RPM while engine
around the sparkplug wire. Meter displays RPM while engine
is running, and accumulated engine running hours when
engine is stopped. Service engine message is reset by
engine is stopped. Service engine message is reset by
passing a magnet across the front of the meter display.
G-8
NOTE: This diagram is for reference only. It may not be accurate for all machines covered by this manual.
ENHANCED DIAGRAM