Billy Goat KD502SPQ Manual De Usuario

Part No. 890257 Form No. F021695H

Page 2 of 12

SAFETY 2

THIS SYMBOL MEANS

THIS SYMBOL MEANS W

W ARNING OR CA

ARNING OR CA

ARNING OR CAUTION.

UTION.

UTION. DEA

DEA

DEATH,

TH,

TH, PERSONAL INJUR

PERSONAL INJUR

PERSONAL INJURY AND/OR PR

Y AND/OR PR

Y AND/OR PRO P E R

O P E R

O P E RTY

D A M A

A M A

A M AGE MA

GE MA

GE MAY OCCUR UNLESS INSTR

Y OCCUR UNLESS INSTR

Y OCCUR UNLESS INSTRUCTIONS ARE FOLLO

UCTIONS ARE FOLLO

UCTIONS ARE FOLLOWED CAREFULL

WED CAREFULL

WED CAREFULLY

BEFORE ST

BEFORE STA R

A R

A RTING ENGINE,

TING ENGINE,

TING ENGINE, READ AND UNDERST

READ AND UNDERST

READ AND UNDERSTAND

AND

AND THE

THE

THE “ENTIRE OPERA

“ENTIRE OPERA

“ENTIRE OPERAT

TOR'S MANU

OR'S MANU

OR'S MANUAL & EN-

AL & EN-

GINE MANU

GINE MANUAL.

AL.

AL.”

”

○

SAFETY INSTRUCTIONS

GENERAL SAFETY

A S S E M B L

A S S E M B LY

PA R

A R

A RTS B

TS B

TS BA

A G & CONTR

G & CONTR

G & CONTRO L S

O L S

LABELS

O P E R A

O P E R ATION

TION

MAINTENANCE

PA R

A R

A RTS DRA

TS DRA

TS DRAWING & LIST

WING & LIST

TROUBLESHOOTING

W ARRANTY PR

ARRANTY PR

ARRANTY PRO C E D U R E

O C E D U R E

○

TABLE OF CONTENTS

ABLE OF CONTENTS

8 - 9

10 - 12

5 - 7

13. DO NOT

DO NOT

DO NOT tamper with governor springs,

governor links or other parts which may

change the governed engine speed.

14. DO NOT

DO NOT

DO NOT tamper with the engine speed

selected by the engine manufacturer.

15. DO NOT

DO NOT

DO NOT check for spark with spark

plug or spark plug wire removed. Use an

approved tester.

16. DO NOT

DO NOT

DO NOT crank engine with spark plug

removed. If engine is flooded, place

throttle in “FAST” position and crank until

engine starts.

17. DO NO

DO NO

DO NOT strike flywheel with a hard

object or metal tool as this may cause

flywheel to shatter in operation. Use

proper tools to service engine.

18. DO NOT

DO NOT

DO NOT operate engine without a

m uffler. Inspect periodically and replace,

necessary. If engine is equipped with

m uffler deflector, inspect periodically and

replace, if necessary, with correct deflector.

19. DO NOT

DO NOT

DO NOT operate engine with an

accumulation of grass, leaves, dirt or other

combustible material in the muffler area.

20. DO NOT

DO NOT

DO NOT use this engine on any forest

covered, brush covered, or grass covered

unimproved land unless a spark arrester is

installed on the muffler. The arrester must

be maintained in effective working order by

the operator. In the State of California the

above is required by law (Section 4442 of

the California Public Resources Code).

Other states may have similar laws.

Federal laws apply on federal lands.

O P E R ATO R

21. DO NO

DO NO

DO NOT touch hot muffler, cylinder, or

fins because contact may cause burns.

22. DO NOT

DO NOT

DO NOT run engine without air cleaner

or air cleaner cover.

23. DO NOT

DO NOT

DO NOT operate during excessive

vibration!

24. DO NOT

DO NOT

DO NOT leave machine unattended

while in operation.

25. DO NOT

DO NOT

DO NOT park machine on a steep

grade or slope.

W ARNING:

ARNING:

ARNING: DO

1. A L

A L

A LW

W A

AYS DO

YS DO

YS DO remove the wire from the

spark plug when servicing the engine or

equipment TO PREVENT ACCIDENTAL

STA RTING.

2. D O

D O

D O keep cylinder fins and governor

parts free of grass and other debris

which can affect engine speed.

3. D O

D O

D O pull starter cord slowly until resis-

tance is felt.

Then pull cord rapidly to avoid

kickback and prevent hand or arm injury.

4. D O

D O

D O examine muffler periodically to be

sure it is functioning effectively. A worn or

leaking muffler should be repaired or

replaced as necessary.

5. D O

D O

D O use fresh gasoline. Stale fuel can

gum carburetor and cause leakage.

6. D O

D O

D O check fuel lines and fittings fre-

quently for cracks or leaks. Replace if

necessary

7. Follow

Follow engine manufacturer operating

and maintenance instructions.

8. Inspect

Inspect

Inspect machine and work area before

starting unit.

VIBRA

VIBRATION

TION

SOUND TESTS

VIBRATION LEVEL 2.7g

Vibration levels at the operators handles were

measured in the vertical, lateral, and longitudinal

directions using calibrated vibration test equipment.

Tests were performed on 05/20/94 under the conditions

listed:

WIND SPEED:

WIND DIRECTION:

HUMIDITY:

T E M P E R ATURE:

BAROMETRIC PRESSURE:

GENERAL CONDI-

TION:

S O U N D

Sound tests conducted were in accordance

with 79/113/EEC and were performed on 05/

20/94 under the conditions listed:

GENERAL CONDI-

TION:

109

30.1" Hg (765mm Hg)

58 %

N.W.

3 MPH (4.8 kmh)

70 F (21.1 C)

WIND SPEED:

WIND DIRECTION:

HUMIDITY:

T E M P E R ATURE:

BAROMETRIC PRESSURE:

Sunny

30.1" Hg (765mm Hg)

58 %

N.W.

3 MPH (4.8 kmh)

70 F (21.1 C)

Sunny

IN THE INTEREST OF SAFETY

THE INTEREST OF SAFETY

○

W ARNING:

ARNING:

ARNING: DO NO

DO NO

DO NOT

1. DO NOT

DO NOT

DO NOT run engine in an enclosed area.

Exhaust gases contain carbon monoxide,

an odorless and deadly poison.

2. DO NOT

DO NOT

DO NOT place hands or feet near moving

or rotating parts.

3. DO NOT

DO NOT

DO NOT store, spill or use gasoline near

an open flame, or devices such as a stove,

furnace, or water heater which use a pilot

light or devices which can create a spark.

4. DO NOT

DO NOT

DO NOT refuel indoors where area is not

well ventilated. Outdoor refueling is

recommended.

5. DO NOT

DO NOT

DO NOT fill fuel tank while engine is

running. Allow engine to cool for 2 minutes

before refueling. Store fuel in approved

safety containers.

6. DO NOT

DO NOT

DO NOT remove fuel tank cap while

engine is running.

7. DO NOT

DO NOT

DO NOT operate engine when smell of

gasoline is present or other explosive

conditions exist.

8. DO NOT

DO NOT

DO NOT operate engine if gasoline is

spilled. Move machine away from the spill

and avoid creating any ignition until the

gasoline has evaporated.

9. DO NOT

DO NOT

DO NOT transport unit with fuel in tank.

10. DO NOT

DO NOT

DO NOT smoke when filling fuel tank.

11. DO NOT

DO NOT

DO NOT choke carburetor to stop

engine. Whenever possible, gradually

reduce engine speed before stopping.

12. DO NOT

DO NOT

DO NOT run engine at excessive

speeds.

This may result in injury & /or

damage to unit.