Raypak 1802B-2342B Fascicule

Catalog No.: 6000.342B

Effective: 8-15-08

Replaces: 3-1-07

Job:

Engineer:

Contractor:

Prepared By:

Date:

Model:

Indoor/Outdoor:

MBTUH Input:

Sealed Combustion Chamber

100% Factory Fire Tested

Efficiency: 85%

Minimum Non-condensing Inlet Temperature: 105°F

Thermal Shock Proof Heat Exchanger

Limited Twenty-year Thermal Shock Warranty

Limited Five-year Heat Exchanger Warranty

Diagnostic Center with Fault History

PolyTuf Powder Coated Cabinet

No Combustible Floor Shield Required

Fan-assisted

Non-ferrous Bypass

Patented Burner Security Blanket

Heat Exchanger
Bronze Headers
ASME Inspected and Stamped

160 PSIG Working Pressure

  National Board Approved
  Cupro Nickel Finned Tubing
  ASME Steel Tube Sheet
  Silicone High Temp O-Rings
  125 PSIG ASME Pressure Relief Valve
  Temperature and Pressure Gauge
  Water Connections

Left – Standard
Right – Option A-6

Bronze Pump, 120V, 60Hz
Non-ferrous Pool Bypass

Controls
  120V, 60Hz, 1∅ Power Supply
  120/24V 60Hz Transformer
  100% Shut-off/Lockout
  Hot Surface Ignition Systems (2)
  Remote Flame Sensors (2)
  High Limit Control, Auto Reset
  On/Off Power Switch
  Manual Shut-off, Front-mounted
  Flow Switch
  Blocked Vent Pressure Switch
  Combustion Air Proving Switches
  Economaster Pump Time Delay
  Poolstat

Gas Train
  Gas Pressure Regulators
  Safety Shut-off Valves
  Firing Control Valves
  On/Off Firing
  Low Gas Pressure Switch, Manual
  Fuel

Natural Gas
Propane Gas

Design Certified ANSI Z21.56/

CSA 4.7

Burner
Ultra-low NOx:

Less than 30 PPM

Construction
Indoor/Outdoor Construction
Enclosed Front Controls

Venting
Vent Location

Top – Standard
Rear – Option D-14

Vent Termination Cap

Outdoor – Option D-11
Indoor, Horizontal –

Option D-15

Indoor, Vertical (by others)

Combustion Air

In-Line Filter Kit (TruSeal

only) – Option D-17

Air Intake Elbow –

Option D-16

Options

C-6

Ignition Module, Manual Reset

D-21 TruSeal™ Direct Vent

Right Side

Left Side (Model 1802B

Only)

F-10 Low Water Cut-off, Remote

Probe

S-2

Dual High Gas Pressure
Switches, Manual Reset

X-1

SureRack Kit, Zone III and IV

X-2

SureRack Add-on, Zone IV

Y-241 Temperature Controller,

1-4 Stages

Regulatory Agency Requirements

G-1

CSD-1

Hi Delta

- Type P

Commercial Pool Heaters

Models 1802B-2342B