Troy-Bilt Series RZT Manuel D’Utilisation

• 

Using a pressure lubricating gun, lubricate the front castor 

wheel axles and the front pivot axle with grease after every 

10 hours of service.

• 

Periodically lubricate all other pivot points with a quality 

lubricating oil.

Once a month remove the belt covers to remove any 

accumulation of grass clippings from around the spindle pulleys 

and V-belt. Clean more often when mowing tall, dry grass.

When using the deck wash system, never 

engage the deck from any position other than the 

operator’s seat of the tractor. Do not use an assistant or 

engage deck in the presence of any bystanders. 

6. 

Attach the nozzle adapter to a standard garden hose 

connected to a water supply. 

7. 

Move the tractor to an area within reach of the hose where 

the dispersal of wet grass clippings is acceptable to you. 

Disengage the PTO, engage the parking brake and stop the 

engine.

8. 

Pull back the lock collar of the nozzle adapter and push the 

adapter onto one of the deck wash nozzles at either end of 

the mower deck. Release the lock collar to lock the adapter 

on the nozzle. See Figure 6-3.

9. 

Turn on the water supply. 

10.  From the tractor operator’s seat, start the engine and 

engage the PTO. Allow to run as needed. Disengage the 

PTO and stop the engine.

11.  Turn off the water supply. 
12.  Pull back the lock collar of the nozzle adapter to disconnect 

the adapter from the nozzle. 

13.  Repeat the previous steps to clean the deck using the 

nozzle at the other end of the deck.

Check the tire air pressure after every 50 hours of operation or 

weekly. Keep the tires inflated to the recommended pressures. 

Improper inflation will shorten the tire service life. See the tire side 

wall for proper inflation pressures. Observe the following guidelines:
• 

Do not inflate a tire above the maximum pressure shown 

on the sidewall of the tire.

• 

Do not reinflate a tire that has been run flat or seriously under 

inflated. Have it inspected and serviced by a  qualified tire 

mechanic.

•  Should battery acid accidentally splatter into 

the eyes or onto the skin, rinse the affected area 

immediately with clean cold water. If there is any 

further discomfort, seek prompt medical attention.
•  If acid spills on clothing, first dilute it with clean 

water, then neutralize with a solution of ammonia/

water or baking soda/water.
•  NEVER connect (or disconnect) battery charger 

clips to the battery while the charger is turned on, as 

it can cause sparks.
•  Keep all sources of ignition (cigarettes, matches, 

lighters) away from the battery. The gas generated 

during charging can be combustible.
•  As a further precaution, only charge the battery 

in a well ventilated area.
•  Always shield eyes and protect skin and clothing 

when working near batteries.
•  Batteries contain sulfuric acid and may emit 

explosive gases. Use extreme caution when handling 

batteries. Keep batteries out of the reach of children.

• 

The battery is filled with battery acid and then sealed at 

the factory. However, even a “maintenance free” battery 

requires some maintenance to ensure its proper life cycle.

• 

Spray the terminals and exposed wire with a battery 

terminal sealer, or coat the terminals with a thin coat of 

grease or petroleum jelly, to protect against corrosion.

• 

Always keep the battery cables and terminals clean and 

free of corrosion.

• 

Avoid tipping. Even a sealed battery will leak electrolyte 

when tipped.

Batteries contain sulfuric acid and may 

emit explosive gases. Use extreme caution when 

handling batteries. Keep batteries out of the reach 

of children.

1. 

When storing the tractor for extended periods, disconnect 

the negative battery cable. It is not necessary to remove 

the battery.

2. 

All batteries discharge during storage. Keep the exterior 

of the battery clean, especially the top. A dirty battery will 

discharge more rapidly.

3. 

The battery must be stored with a full charge. A discharged 

battery can freeze sooner than a charged battery. A fully 

charged battery will store longer in cold temperatures than hot.