Roberts Gorden CRV-B-12 Manuale Utente
© 2006
ROBERTS GORDON, LLC
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon, LLC.
TABLE OF CONTENTS
SECTION 1: Heater Safety...................................................... 1
1.1 Manpower Requirements ............................................. 1
SECTION 2: Installer Responsibility ..................................... 2
2.1 Wall Tag ....................................................................... 2
2.2 Corrosive Chemicals.................................................... 2
2.3 National Standards and Applicable Codes .................. 2
2.2 Corrosive Chemicals.................................................... 2
2.3 National Standards and Applicable Codes .................. 2
SECTION 3: Critical Considerations...................................... 3
3.1 Required Clearances to Combustibles......................... 3
SECTION 4: National Standards and Applicable Codes ..... 7
4.1 Gas Codes................................................................... 7
4.2 Aircraft Hangars ........................................................... 7
4.3 Public Garages ............................................................ 7
4.4 Electrical ...................................................................... 7
4.5 Venting......................................................................... 7
4.6 High Altitude ................................................................ 7
4.2 Aircraft Hangars ........................................................... 7
4.3 Public Garages ............................................................ 7
4.4 Electrical ...................................................................... 7
4.5 Venting......................................................................... 7
4.6 High Altitude ................................................................ 7
SECTION 5: Major Components ............................................ 8
5.1 Standard Parts List .................................................... 11
SECTION 6: Design Requirements ...................................... 13
SECTION 7: Heater Installation............................................ 15
SECTION 7: Heater Installation............................................ 15
7.1 Tube Installation ........................................................ 16
7.2 Coupling and Tube Assembly.................................... 16
7.3 Elbow Package Configuration..................................... 17
7.4 Reflector Installation .................................................. 18
7.5 Burner Installation...................................................... 20
7.2 Coupling and Tube Assembly.................................... 16
7.3 Elbow Package Configuration..................................... 17
7.4 Reflector Installation .................................................. 18
7.5 Burner Installation...................................................... 20
SECTION 8: Optional Heater Accessories .......................... 21
8.1 Tee Installation .......................................................... 21
8.2 Reflector Joint............................................................ 21
8.3 Reflector Side Extension............................................ 23
8.4 Universal Shield ......................................................... 24
8.5 Barrier Shield ............................................................. 24
8.6 Two-Foot Decorative Grille Installation....................... 25
8.7 One-Foot Decorative Grille Installation ...................... 26
8.8 Protective Grille Installation........................................ 29
8.9 Classic Cast-Iron Components ................................. 30
8.2 Reflector Joint............................................................ 21
8.3 Reflector Side Extension............................................ 23
8.4 Universal Shield ......................................................... 24
8.5 Barrier Shield ............................................................. 24
8.6 Two-Foot Decorative Grille Installation....................... 25
8.7 One-Foot Decorative Grille Installation ...................... 26
8.8 Protective Grille Installation........................................ 29
8.9 Classic Cast-Iron Components ................................. 30
SECTION 9: Pump Installation and Venting ....................... 31
9.1 Pump Installation ....................................................... 31
9.2 General Venting Requirements Model EP-100,
EP-200 and EP-300 Series Pumps ............................ 32
9.3 Horizontal Venting 4" (10 cm) Pipe ............................ 34
9.2 General Venting Requirements Model EP-100,
EP-200 and EP-300 Series Pumps ............................ 32
9.3 Horizontal Venting 4" (10 cm) Pipe ............................ 34
SECTION 10: Outside Air Supply......................................... 37
10.1 Pressurized .............................................................. 37
10.2 Non-Pressurized ...................................................... 37
10.3 Outside Air Blower Internal Wiring ........................... 38
10.2 Non-Pressurized ...................................................... 37
10.3 Outside Air Blower Internal Wiring ........................... 38
SECTION 11: Gas Piping ...................................................... 41
SECTION 12: Control Methods ............................................ 42
12.1 ROBERTS GORDON
®
System Control ................... 42
12.2 ROBERTS GORDON
®
ULTRAVAC
TM
..................... 42
12.3 SPST Transformer Relay (P/N 90417600) ............... 42
12.4 DPST Transformer Relay (P/N 90436300)............... 42
12.4 DPST Transformer Relay (P/N 90436300)............... 42
SECTION 13: Starting The System ...................................... 49
13.1 Checking the Gas Line ............................................ 49
13.2 Checking the Electrical System ............................... 49
13.3 Starting the System ................................................. 49
13.4 Setting the Vacuum.................................................. 49
13.2 Checking the Electrical System ............................... 49
13.3 Starting the System ................................................. 49
13.4 Setting the Vacuum.................................................. 49
SECTION 14: Operation and Maintenance.......................... 51
14.1 Sequence of Operation............................................ 51
14.2 To Shut Off Heater ................................................... 51
14.3 To Start Heater ........................................................ 51
14.4 Pre-Season Maintenance and Annual Inspection.... 51
14.5 Maintenance Checklist............................................. 52
14.2 To Shut Off Heater ................................................... 51
14.3 To Start Heater ........................................................ 51
14.4 Pre-Season Maintenance and Annual Inspection.... 51
14.5 Maintenance Checklist............................................. 52
SECTION 15: Troubleshooting............................................. 55
15.1 Troubleshooting Flow Chart ..................................... 55
SECTION 16: Replacement Parts ........................................ 57
SECTION 17: General Specifications .................................. 58
SECTION 17: General Specifications .................................. 58
17.1 Material Specification ............................................... 58
17.2 Heater Specifications ............................................... 58
17.3 Suspension Specifications ....................................... 58
17.4 Controls Specifications ............................................. 58
17.2 Heater Specifications ............................................... 58
17.3 Suspension Specifications ....................................... 58
17.4 Controls Specifications ............................................. 58
SECTION 18: The ROBERTS GORDON
®
CORAYVAC
®
Limited Warranty............................................ 61
Printed in U.S.A.