Kawasaki STX-15F Manuale Utente
14-26 ELECTRICAL SYSTEM
Electric Starter System
Starter Relay Removal
•
Remove:
Seat (see Hull/Engine Hood chapter)
Rear Storage Pocket (see Hull/Engine Hood chapter)
Battery (see this chapter)
Rear Storage Pocket (see Hull/Engine Hood chapter)
Battery (see this chapter)
•
Disconnect the negative battery cable from the battery
terminal. (see Battery Removal).
terminal. (see Battery Removal).
•
Disconnect the starter relay lead connector [A].
•
Slide out the rubber caps [A].
•
Remove the nuts [B] from the battery and starter terminals
on the start relay switch.
on the start relay switch.
•
Remove the starter relay case bolts [C] and slide the
starter relay switch from the relay case [D], being care-
ful not to lose any of the insulating washers or grommets.
starter relay switch from the relay case [D], being care-
ful not to lose any of the insulating washers or grommets.
Starter Relay Installation
•
Mount the starter relay switch [A] in the relay case [B].
○
Coat the insulating washers [C] and grommets [D] with
water resistant grease.
water resistant grease.
○
Be certain all insulating washers and grommets are in po-
sition.
sition.
○
Tighten the relay mounting nuts [E] securely.
Torque - Starter Relay Mounting Nuts: 4 N·m (0.40 kgf·m,
35 in·lb)
•
Replace the gasket [A] with a new one.
•
Be sure the dowel pins [B] are in position.
•
Be sure the grommet [C] is installed on the relay case [D].
•
Be sure the battery cable is connected to the battery ter-
minal having red mark.
minal having red mark.
Torque - Starter Relay Case Bolts: 7.8 N·m (0.80 kgf·m, 69
in·lb)
Starter Cable Mounting Nuts: 4 N·m (0.40 kgf·m,
35 in·lb)
Starter Relay Inspection
•
Remove the starter relay (see Starter Relay Removal).
•
Set hand tester to R × 1 Ω range.
•
Connect meter leads to starter relay as shown.
If resistance is less than infinite, the starter relay switch is
not returning and must be replaced.
If resistance is less than infinite, the starter relay switch is
not returning and must be replaced.
Special Tool - Hand Tester: 57001-1394