Kohler courage xt-7 ユーザーズマニュアル
10
Maintenance Instructions
Frequency
Maintenance Required
After First 3-5 Hours of Operation
Change oil
Daily or Before Starting Engine
Fill fuel tank
Check oil level.
Check air intake and cooling areas; clean as necessary¹
Yearly or Every 25 Hours
Service or replace precleaner element (if equipped)¹
ȱȱȱȱȱęȱȱ¢ǰȱȱȱȱŵ
Yearly or Every 50 Hours
ȱȱęȱǻȱǼ
Change oil
Yearly or Every 100 hours
Replace spark plug and set gap
ȱȱȱęŵ
ȱȱȱę
Adjust valves
Ř
Clean combustion chamber
Ř
Figure 12. Maintenance Table.
¹Perform these maintenance procedures more frequently under extremely dusty, dirty conditions.
2
These procedures should be performed by a Kohler Authorized Service Center.
Oil Level Check
The importance of checking and maintaining
the proper oil level in the crankcase cannot be
overemphasized.
the proper oil level in the crankcase cannot be
overemphasized.
Check oil BEFORE EACH USE as follows:
1.
Make sure the engine is stopped, level, and cool
so the oil has had time to drain into the sump.
so the oil has had time to drain into the sump.
Řǯȱ
ȱȱȱȱȱȱęȱȦȱȱ
keep dirt and grass clippings out of the engine.
keep dirt and grass clippings out of the engine.
řǯȱ
ȱȱȱȱȱęȱȦDzȱ
ȱěȱǯȱȱȱȱȱȱȱ
ȱȱȱȱęȱȱȱȱǯȱDO NOT
screw the cap into the tube. See Figure 13.
ȱěȱǯȱȱȱȱȱȱȱ
ȱȱȱȱęȱȱȱȱǯȱDO NOT
screw the cap into the tube. See Figure 13.
Oil Fill Cap/Dipstick
Figure 13. Oil Fill Cap/Dipstick.
Śǯȱ
ȱȱȱȱȱȱǯȱȱ
should be up to, but not over F or FULL mark on
ǯȱȱȱŗŚǯ
should be up to, but not over F or FULL mark on
ǯȱȱȱŗŚǯ
Operating
Range
Full Mark
Low Mark
Figure 14. Oil Level Dipstick.
śǯȱ
ȱȱȱȱ ǰȱȱȱȱ¢ȱȱȱȱȱ
the F or FULL mark on dipstick. Always check the
oil level with the dipstick before adding more.
the F or FULL mark on dipstick. Always check the
oil level with the dipstick before adding more.
Ŝǯȱ
ȱȱęȱȦȱȱȱ¢ǯ
NOTE: To prevent extensive engine wear or damage,
always maintain proper oil level in crankcase.
Never operate engine with oil level below the
L or LOW mark, or over the F or FULL mark
on dipstick.
Never operate engine with oil level below the
L or LOW mark, or over the F or FULL mark
on dipstick.