FiveStar 634Fivestar インストールガイド

Plan installation carefully. Before installing roof cap, make
sure that birdscreen is in place. Refer to Figure 3 under “MAIN-
TENANCE” section.

Roof cap will accept up to 3¼” x 10” rectangular or 8” round
duct. Ductwork may enter roof cap as shown in Figures 1A &
1B. Tape all joints with duct tape to prevent air and water
leaks.

1. Cut hole in roof approximately ½” larger than ductwork.

2. Insert ductwork through opening and run it back to fan or

range hood. Leave a maximum of ¾” of duct projecting
above roof surface on the high side.

3. Trim ductwork parallel to roof pitch.

To replace damper flap or gasket material:

1. Remove birdscreen, using sharp pointed tool. Pull screen

down and pop it out. (Figure 3)

2. Remove screw (Item #8) in center of damper plate assem-

bly and pull assembly out.

3. Pull out damper rod and lift damper flap out.

4. Replace defective or worn parts and reinstall damper flap

with rib in flap facing up.

5. Slide damper plate assembly into grooves on inside of cap

and replace screw. Make sure that damper opens freely.

6. Replace screen and position as shown.

NOTE: The high quality paint coating on our outdoor acces-
sories may be used as the exterior finish or as a prime coat
for the finish of your choice. Apply the coating best suited for
the special conditions of your application.

Damper Plate (Painted) 98005584
Damper Plate (Aluminum) 98005598

Bird Screen
98005577

Housing (Painted) 97006176
Housing (Aluminum) 97006250

Screw (Black) 99170245
Screw (Silver) 99150576

Long Sealant
Strip 99500321

Short Sealant
Strip 99500322

Damper
Rod
98005576

Damper Flap
98005581

99040511G

Figure 3

4. Carefully lift shingles and slide back flange of roof cap

under shingles. Nail flange to roof under shingles at top
two corners and two sides. Nail directly to roof in four
places at bottom. (Figure 2)

5. Use roof cement to seal shingles to top and sides of roof

cap. Seal all nail heads with roof cement as well.

NAILS

(Seal all nail heads with roof cement)

ROOF CEMENT

(Seal shingles to roof cap

on sides and top)

Figure 2

Figure 1A

Figure 1B