BMW 2005 Z4 Roadster 2.5i Manual Do Proprietário

Special operating instructions

Break-in procedures

Moving parts need to be given some time until
they can interact smoothly with one another. To
ensure that your vehicle provides maximum
economy throughout a long service life, we
request that you observe the following:

Engine and differential

Up to 1,200 miles/2,000 km:
Drive at varying engine and road speeds, but do
not exceed the following engine or road speed:
4,500 rpm / 4,500/min or 100 mph / 160 km/h.
Obey your local and state maximum speed lim-
its.
Refrain from using full throttle and avoid press-
ing the accelerator beyond the kickdown point.
After you have driven 1,200 miles/2,000 km,
you can gradually increase the engine or road
speeds.

Sequential manual gearbox SMG

Up to 1,200 miles/2,000 km:
Do not use the acceleration assistant during the
break-in period.

Tires

Due to technical factors associated with their
manufacture, tires do not achieve their full trac-
tion potential until an initial break-in period has
elapsed. You should therefore drive with extra
caution during the first 200 miles/300 km.
Obey your local and state maximum speed lim-
its.

When the vehicle is operated on wet or
slushy roads, a wedge of water may form

between the tire and the road surface. This phe-
nomenon is referred to as hydroplaning and can
lead to partial or complete loss of traction, vehi-
cle control and braking effectiveness. Reduce
your speed on wet roads.

Brake system

Approx. 300 miles/500 km must elapse before
the brake pads and rotors achieve their optimal
surface and wear pattern.
To break in the separate parking brake drums,
apply the parking brake lightly when coasting to
a standstill – at a traffic signal, for instance; use
caution to avoid posing a danger to other road
users.
To avoid corrosion, repeat this procedure from
time to time.
The brake lamps do not come on when the
parking brake is set.

Vacuum for the brake system servo unit
on your BMW is available only when the

engine is running. When you move the car with
the engine off, e.g. by towing, substantially
higher levels of pedal force will be required to
brake the vehicle.

Clutch

The clutch will achieve its optimal functionality
after approx. 300 miles/500 km. Shift gears
carefully during the break-in period.

After replacing components

Follow the same break-in procedure again if any
of the components mentioned above have to be
replaced in the future.

Driving notes

Close the luggage compartment lid

Operate the vehicle only when the lug-
gage compartment lid is completely

closed, otherwise exhaust fumes could pene-
trate into the interior of the vehicle.

Should it be absolutely necessary to operate
the vehicle with the luggage compartment lid
open and with the convertible top closed: