Справочник Пользователя для I.C.T.C. Holdings Corporation B series

7 

 
If shutting down for a short period of time, it is sufficient to trigger the gun to 
relieve pressure. Then set the safety lock on gun to "locked" position with the 
gun locked closed and immerse the gun in a container of the correct thinner for 
the paint you are spraying. 
 
If shutting down at job completion, for the night, or to change colors; 
 
1.     Turn pressure control knob counter clockwise to low pressure setting.  
2.     Switch unit “OFF”. Remove spray  tip from gun and trigger gun back into 
paint        tank. Direct against side of tank. 
3.     Remove and discard strainer bag. 
4.     To remove any remaining paint from the paint tank, tip unit as shown and 
        pour into original container. Allow plastic liner to fall into container. Remove 
        and  discard liner. 
5.     Upright unit and add one(1) gallon of the correct thinner, for the paint being 
        used, to the paint tank. 
6.     Re-start unit and trigger gun back into the paint tank. Direct against the sides 
        of the tank. Use the stream to clean the sides and bottom. Circulate the thinner 
        for several minutes. 
7.     Remove dirty thinner, per step 4 and repeat steps 5 & 6 with fresh thinner. 
        Trigger gun into waste container until tank runs dry. 
8.     Repeat procedure using a gallon of pre-mixed H.E.R.O. Equipment Wonder 
        Wash  solution. If  not using Wonder Wash, unit  must not be stored with 
        water. Only store with a non corrosive material ( Paint thinner, solvent ).   
9.     Switch unit "off" and trigger gun to relieve remaining pressure. 
10.   Remove and rinse gun handle filter in correct thinner. 
    
 
 

In areas where the sprayer is NOT used 12 months of the year, special preparations 
must be used for winter or off season storage. Because solvents evaporate quickly, 
they should not be used for long term storage. A petroleum based solution ( solvent 
and oil ) should be used as an extended storage material. DO NOT allow storage 
solution to freeze in the sprayer. 
 
 
 
H.E.R.O. Equipment Wonder Wash, available from your H.E.R.O. distributor, 
will provide the added cleaning benefits of solvent at a much lower cost. Suitable 
as a short term ( 1-2 days ) storage solution only