Burnham MST513 用户手册

WARNING

This boiler contains very hot water under high pressure. Do not unscrew any pipe fittings nor attempt

to disconnect any components of this boiler without positively assuring the water is cool and has no

pressure. Always wear protective clothing and equipment when installing, starting up or servicing this

boiler to prevent scald injuries. Do not rely on the pressure and temperature gauges to determine the

temperature and pressure of the boiler. This boiler contains components which become very hot when

the boiler is operating. Do not touch any components unless they are cool.
This boiler must be properly vented. The chimney must be inspected for any obstructions and cleaned

prior to each heating season. A clean and unobstructed chimney flue is necessary to produce the minimum

draft required to safely evacuate noxious fumes that could cause personal injury or loss of life. Evidence

of loose debris and or condensate induced stains at the base of the chimney flue, connector or smokepipe

joints may be signs of condensing flue gases. Flue gas condensate is corrosive, which requires special

consideration and must be addressed immediately. Refer to Section V, "Venting and Air Intake Piping".
This boiler needs fresh air for safe operation and must be installed so there are provisions for adequate

combustion and ventilation air.
This boiler is supplied with controls which may cause the boiler to shut down and not re-start without

service. If damage due to frozen pipes is a possibility, the heating system should not be left unattended in

cold weather; or appropriate safeguards and alarms should be installed on the heating system to prevent

damage if the boiler is inoperative.
This boiler is designed to burn No. fuel oil only. Do not use gasoline, crankcase drainings, or any oil

containing gasoline. Never burn garbage or paper in this boiler. Do not convert to any solid fuel (i.e.

wood, coal). Do not convert to any gaseous fuel (i.e. natural gas, LP). All flammable debris, rags, paper,

wood scraps, etc., should be kept clear of the boiler at all times. Keep the boiler area clean and free of

fire hazards.
All boilers equipped with burner swing door have a potential hazard which, if ignored, can cause severe

property damage, personal injury or loss of life. Before opening swing door, unplug burner power cord

from receptacle located in lower right corner of jacket front panel and turn off service switch to boiler

to prevent accidental firing of burner outside the combustion chamber. Be sure to tighten swing door

fasteners completely when service is completed.

TABLE OF CONTENTS

I. Pre-Installation . . . . . . . . . . . . . . . . . . . . 7

VII. Oil Piping . . . . . . . . . . . . . . . . . . . . . . . 37

II. Unit-Pak Boiler Assy . . . . . . . . . . . . . . . 9

VIII. System Start-Up . . . . . . . . . . . . . . . . . . 39

III. Steam Boiler Trim & Piping . . . . . . . . . . . 22

IX. Maintenance & Service Instructions . . . 45

IV. Tankless & Indirect Water Heater Piping . 24

X. Boiler Cleaning . . . . . . . . . . . . . . . . . . . 48

V. Venting & Air Intake Piping . . . . . . . . . . 27

XI. Trouble Shooting . . . . . . . . . . . . . . . . . 50

VI. Electrical . . . . . . . . . . . . . . . . . . . . . . . . 32

XII. Repair Parts . . . . . . . . . . . . . . . . . . . . . 51