Raypak 503 thru 2003 用户手册

ASME, National Board Registered, 160 PSI

• HLW Stamp

N/A

• H Stamp

N/A

Heat Exchanger Tubes

• Copper

• Cupro Nickel

Bronze Headers

Cast Iron Headers

N/A

Pressure Relief Valve

• 60 PSI

• 125 PSI

• 30, 45, 75, 150 PSI

Temperature & Pressure Gauge

Pump

• 120V, Single-Phase

Indoor/Outdoor Certified

Vent Terminal

• Outdoor

• Through-the-Wall

Fully-Enclosed Controls

Combustible Floor Rated

120V Power Supply with 120V/24V Transformer

On/Off Switch

Programmable Pump Time Delay, Single-Phase

• Included in TempTracker Mod Controller

Terminal Block Connections

• Enable / Disable

• External Interlocks

• 0-10 VDC Setpoint/Direct Drive Input (cat. I)

12 Diagnostic Lights with 256-Event History

Status Display Lights (4)

Temperature Controller with 3 Water Sensors

• TempTracker Mod (up to 4:1 Turndown, cat. IV)

• Outdoor Reset Sensor

N/A

Multiple Boiler Controller

• TempTracker Mod+, up to 16 boilers

• Y-200, up to 40 boilers (LonWorks optional)

Hot Surface Ignition System

• 1-try (standard on cat. IV)

• 3-try (standard on cat. I)

High/Low Gas Pressure Switches

Blocked Vent and Air Pressure Switches

High Limit Switch

• Manual Reset, Fixed

• Manual Reset, Adjustable

• Automatic Reset, Adjustable

Low Water Cut-Off, 24V

• With Manual Reset and Test Buttons

Flow Switch

Modulating Combination Gas Valve

Combustion Air Blower

TruSeal Direct-Vent Ready

Additional Safety Valve

• Motorized (externally mounted)

• Solenoid (externally mounted)

CSA-Certified Efficiency

• Cat. IV - 87% at Full Fire

• Cat. I - 84% to 85% (see MBTUH table)

Air Filter

Alarm System

CSD-1 / GE GAP Control System

Low NOx

• Meets all current requirements

Cold Water Start

• Prevents internal condensation on start-up

Cold Water Run

• Prevents condensation in continuous low-temp operation

Water Heaters

(Type WH)

Boilers

(Type H)

 

 

= Standard       

 

 

= Optional

Raypak, Inc. •  2151 Eastman Avenue, Oxnard, CA 93030 • phone: (805) 278-5300 • fax: (800) 872-8725 • www.raypak.com

Cat. No. 3400.11E    Effective 07-01-08    Replaces 11-1-07