Alto-Shaam 1010ESG 用户手册

COMBITOUCH

TM

 ESG SERIES • GAS INSTALLATION MANUAL • 10.

45-3/16"

(1148mm)

42-7/16"

(1077mm)

22-11/16"

(575mm)

12-13/16"

(325mm)

Water Drain

(Bottom)

2-3/16"

(56mm)

30-5/8"

(778mm)

32-13/16"

(833mm)

44" (1118mm)

2"

(50mm)

31-3/4"

(805mm)

8-15/16" (226mm)

49-13/16"  (1265mm)

47-7/8"  (1215mm)

[A,B] 4-3/8"  (110mm)

[D] 4-9/16"  (116mm)

[C] 3-9/16"

(89mm)

Water Drain

(Side Back)

Steam Vent

(Top)

[D] 4-5/8" (116mm)

2" (50mm)

55-7/16"

(1407mm)

73-13/16" (1875mm)

5-7/8" (148mm)

17-1/4" (438mm)

19-11/16"  (500mm)

26-9/16" (675mm)

19-15/16"

(506mm)

D

A = UNTREATED WATER
B = TREATED WATER
C = ELECTRICAL
D = GAS

C

B

A

54-1/8" (1374mm)

40-5/8" (1032mm)

49-9/16" (1258mm)

7-7/8" (200mm)

H x W x D

54-1/8” x 49-13/16” x 45-3/16” (1374mm x 1265mm x 1148mm)

54-1/8” x 53-13/16” x 45-3/16” (1374mm x 1367mm x 1148mm)

33-7/8” x 25-1/4” x 33-7/8” (860mm x 640mm x 860mm)

 (

CONNECTED ENERGY LOAD:

105,000 Btu / hr

Oven must be installed level.
Hood installation is required.
Water supply shut-off valve and back-flow preventer.
Alternate burner orifice is required for installation sites at 

elevations of 2,000 feet (610m) above sea level.

HOOK-UP:  3/4” 

NPT

MINIMUM CONNECTED PRESSURE:  

5.5”  W.C. (Natural Gas)
9”  W.C.  (Propane) 

MAXIMUM CONNECTED PRESSURE:  

14”  W.C. 

10●20ESG

10●20ESG / sk

VOLTAGE PHASE

CYCLE/HZ 

AWG

AMPS

kW

AMPS

kW

110 – 120

1

50/60

 NEMA 5-20P, 20A, 125V Plug, AWG 12

9.2

1.05

13.7

1.57

  Range 200 – 415V – 1 or 3 ph, 50 or 60 Hz

NET

573 lb est   (260 kg)

FULL-SIZE PANS:  20” x 12” x 2-1/2” 

Twenty (20)

SHIP

875 lb  

 (397 kg)

GN  1/1:     530 x 325 x 65mm 

Twenty (20)

CRATE DIMENSIONS:  (L x W x H)

GN 2/1:    650 x 530 x 65mm 

Ten (10)

45” x 53” x 59”

FULL-SIZE SHEET PANS:*

18” x 26” x 1”

Ten (10)

(1143 x 1346 x 1499mm)

ON WIRE SHELVES ONLY

240 lb (109 kg) MAXIMUM

VOLUME MAXIMUM: 150 quarts (190 liters)

*ADDITIONAL WIRE SHELVES REQUIRED FOR MAXIMUM CAPACITY

ONE (1) TREATED WATER INLET:        3/4” NPT*
ONE (1) UNTREATED WATER INLET:  3/4” NPT*
LINE PRESSURE:                                      30 to 90 psi    2.8 to 6.2 bar

WATER DRAIN: 1-1/2” CONNECTION WITH A 2” MINIMUM 

AIR GAP INSTALLED AS CLOSE TO THE OVEN AS POSSIBLE

USING A WATER SUPPLY NOT MEETING ALTO-SHAAM’S MINIMUM 
WATER QUALITY STANDARDS WILL VOID THIS WARRANTY. 
It is the responsibility of the purchaser to ensure that incoming water supply is 
compliant with the specifi cations listed through adequate treatment measures. 
Installation of the CombiGuard

TM

 Water Filtration System is recommended, but 

this system may not address all water quality issues present.

Free Chlorine

Hardness

Chloride

pH

Alkalinity

Silica

Total Dissolved Solids (tds)

Less than 0.1 ppm (mg/L)

Less than 3 gpg (52 ppm)

Less than 30 ppm (mg/L)

7.0 to 8.5

Less than 50 ppm (mg/L)

Less than 12 ppm (mg/L)

Less than 60 ppm

LEFT 6” (152mm) 

20” (508mm) 

RIGHT 4” (102mm)   TOP: 20” (508mm) 

FOR AIR MOVEMENT

BACK 4” (102mm)   BOTTOM: 5-1/8” (130mm) 

FOR LEGS

* Can manifold off of 

one 3/4” line.