England's Stove Works 25-PDV User Manual

Page of 24
 
INSTALLATION & OPERATION MANUAL  
MODEL NUMBERS:   
  25-PDV, 55-SHP22, and 55-TRP22 
25-PDVE, 55-SHP22E, and 55-TRP22E 
 
Thank you for purchasing this product from a fine line of heating equipment. We wish you many 
years of safe heating pleasure with your new heating appliance. 
 
Save These Instructions. 
 
IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO 
THE DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489. 
 
 
 
 
 
 
 
 
 
 
 
Please Note the Following Precautionary Statements: 
 
NOTE:  WE DO NOT RECOMMEND PELLET STOVES AS YOUR ONLY SOURCE OF HEAT. 
     
 
 
 
CAUTION:  Please read this entire manual before installation and use of this  
pellet fuel burning room heater.  
Keep children, furniture, fixtures and all combustibles away from any heating appliance. 
 
WARNING: USE OF OUTSIDE AIR IS MANDATORY WITH THIS UNIT. 
DO NOT OPERATE UNIT WITH HOPPER OPEN.  LID MUST BE SHUT AND TIGHTLY SECURED.
  
DO NOT OPERATE WITH DOOR OPEN
 
 
SAFETY NOTICE 
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE, 
BODILY INJURY OR EVEN DEATH. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL 
THE INSTALLATION INSTRUCTIONS. CONTACT YOUR LOCAL BUILDING OR FIRE 
OFFICIALS FOR RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS 
(INCLUDING PERMITS) IN YOUR AREA. 
 
 
  
Questions?  Need Parts or Options?  
www.englandsstoveworks.com
 
 
 
 
 
Rev. 10/05 
England’s Stove Works highly recommends the use of smoke detectors and 
Carbon Monoxide detectors with any hearth product, including this unit.  Follow all 
manufacturer’s instructions when using smoke or Carbon Monoxide detectors. 
Mobile Home Use: 
These freestanding pellet units are approved for mobile home or doublewide installation with 
outside combustion air hook-up.  See  “Flue System” section of manual. 
Mobile home installation should be in accordance with the Manufactured Home and Safety 
Standard (HUD), CFR 3280, Part 24. 
WARNING:  Do Not Install in Sleeping Room 
CAUTION:  The structural integrity of the mobile home floor, wall and ceiling/roof must 
be maintained.   
 

Summary of Contents of user manual for England's Stove Works 25-PDV

  • Page 1 INSTALLATION & OPERATION MANUAL MODEL NUMBERS: 25-PDV, 55-SHP22, and 55-TRP22 25-PDVE, 55-SHP22E, and 55-TRP22E Thank you for purchasing this...
  • Page 2 A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's...
  • Page 3 IMPORTANT INFORMATION 1. Check local installation codes for your area. Call your Homeowner’s Insurance representative for inspection of your...
  • Page 413. This unit should be turned off and allowed to cool prior to cleaning. Any ashes should be kept in...
  • Page 5 touch pad. This will start the upper auger, bottom auger and exhaust blower. The room air blower will start...
  • Page 6 FLUE SYSTEM Caution: Follow the pipe manufacturer’s installation instructions and directions for passing through combustible walls and ceilings. Be...
  • Page 7 Through the Ceiling When venting the stove through the ceiling, the pipe is connected the same as through the...
  • Page 8 Freestanding Pellet Installation Caution: Follow the pipe manufacturer’s installation instructions and directions for passing through combustible walls and ceilings....
  • Page 9 OPERATING INSTRUCTIONS CAUTION: DO NOT OPERATE WITH THE DOOR OPEN. If door is left open (approximately) two minutes, unit...
  • Page 10any firestarter on any hot surface or hot coals. Never use gasoline, lantern fuel, kerosene, charcoal lighter fluid, diesel fuel...
  • Page 11 DAILY OPERATION Refueling the Unit Always press the “OFF” touch pad before refueling. This stove has a (approximately) 60-lb....
  • Page 12 NOTE: The instructions below concerning the cleaning of the burn pot and wear plate area are especially important to the...
  • Page 13 Annual Cleaning The stove and the flue system should be given a complete cleaning at the end of the...
  • Page 14NOTE: Follow the same procedure to work on the bottom auger, with the exception that the pellets do not have...
  • Page 15 Control Board The Control Board (Part #PU-CB04) is a digital read-out board. This board offers a wide variety of...
  • Page 16Illustration 2b Control Board Diagram (Wiring) CAUTION: Moving Parts May Cause Injury. Do NOT Operate with Panel(s) Off. DANGER: Parts...
  • Page 17 ACCESSORY ITEMS The following accessories can be added to your unit at anytime after purchase; however, let the unit...
  • Page 18 REPLACEMENT PARTS, ACCESSORIES AND OPTIONS AC-GGK Glass Gasket Kit (gasket only, no glass) AC-DGKC Door Gasket Kit (#2 on...
  • Page 19 Pellet Stove – Exploded View Diagram Illustration 4
  • Page 20HOPPER LID LATCHES Illustration 3 – Important: Hopper Lid Latches must be checked periodically Hopper Lid Latches and kept tight...
  • Page 21 TROUBLE-SHOOTING GUIDE WARNING: TO AVOID ELECTRICAL SHOCK ALWAYS DISCONNECT THE UNIT FROM THE POWER SOURCE BEFORE ATTEMPTING ANY REPAIR....
  • Page 22Have this information on hand if you phone the factory or your dealer regarding this product. Retain for your files:...
  • Page 23 WARRANTY REGISTRATION for England’s Stove Works Purchased by (Name) ______________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ Telephone...
  • Page 24