Raypak 182-400 Dépliant
Catalog No.: 2000.205D
Effective: 1-1-08
Replaces: 4-1-05
Job:
Engineer:
Contractor:
Prepared By:
Date:
Model:
Indoor
EFFICIENT
82% efficiency – highest of any atmospheric boiler
82% efficiency – highest of any atmospheric boiler
available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum operating temperature: 230°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby and
Cuts fuel costs substantially because the standby and
radiation losses normal to other boilers and
tank-type water heaters are eliminated
tank-type water heaters are eliminated
LOW WATER OPERATING TEMPERATURE
Operates with water temperature as low as
Operates with water temperature as low as
105°F without condensing
Heat Exchanger
ASME Inspected and Stamped
ASME Inspected and Stamped
160 PSIG
National Board Approved
Headers
Headers
Cast Iron Glass-lined – Standard
Bronze – Option A-1
Bronze – Option A-1
Finned
Tubing
Copper – Standard
Cupro Nickel – Option A-3
Cupro Nickel – Option A-3
ASME Steel Tube Sheet
Silicone
Silicone
O-Rings
ASME Pressure Relief Valve
45 PSIG – Standard
PSIG ASME – Optional
PSIG ASME – Optional
Temperature and Pressure Gauge,
Shipped Loose
Water
Connections
Left Hand – Standard
Right Hand – Option A-6
Right Hand – Option A-6
Flow Configuration – Two-pass
Pump – Optional
Pump – Optional
Mounted, 1/8 HP, 120 Volt, 1
∅, 60 Hz
Controls
120V, 60Hz, 1 Ph Power Supply
120/24V
120V, 60Hz, 1 Ph Power Supply
120/24V
Transformer
100% Pilot Shut-off/Lockout
Electronic,
Electronic,
Intermittent Ignition (IID) Pilot
High Limit Control, Manual Reset
On/Off
On/Off
Switch
Flow
Switch
Economaster II Pump Time Delay
Gas Control Train
Manual Main Gas Shut-off Cock
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Firing
Manual Main Gas Shut-off Cock
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Firing
Mode
On/Off (H4)
Two-stage Firing (H3)
Mechanical Modulation,
Two-stage Firing (H3)
Mechanical Modulation,
110-170°F (H5)
Mechanical Modulation,
150-210°F (H1)
Fuel
Natural Gas
Propane Gas
Propane Gas
Design Certified ANSI Z21.13
Construction
Front
Front
Controls
Stainless Steel Burners
Polytuf Powder Coat Finish
Vent
Polytuf Powder Coat Finish
Vent
Selection
Draft Diverter – Option D-10
Power Vent, Loose – Option D-2
Power Vent, Loose – Option D-2
Base
(Optional)
Combustible Floor Shield –
Option J-1
Temperature Controls
Note: H1 and H5 do not require a
controller
B-6
Two-stage – 100-200ºF
Y-241 Electronic Sequencer,
1-4 Stages
Y-281 Electronic Sequencer,
1-8 Stages
Additional Safety Controls
F-10 Low Water Cut-off Probe
I-1
I-1
High Limit Control, Auto
Reset, 240°F
Reset, 240°F
S-1
Low Gas Pressure Switch,
Manual
Manual
S-2
High Gas Pressure Switch,
Manual
Manual
Regulatory Agency Requirements
Raytherm
®
- Type H
Hydronic Heating Boilers
Models 182-400 - Indoor